Журналы →  Gornyi Zhurnal →  2017 →  №10 →  Назад

EQUIPMENT AND MATERIALS
Название Assessment of durability of sectional pumps in underground kimberlite mines of ALROSA
DOI 10.17580/gzh.2017.10.08
Автор Ovchinnikov N. P., Zyryanov I. V.
Информация об авторе

Mining Institute, Ammosov North-Eastern Federal University, Mirny, Russia:

N. P. Ovchinnikov, Head of Chair, Candidate of Engineering Sciences, ovchinnlar1986@mail.ru

 

Mirny Polytechnic Institute (Branch), Ammosov North-Eastern Federal University, Mirny, Russia:
I. V. Zyryanov, Head of Chair, Doctor of Engineering Sciences

Реферат

feature of sectional pumps had fitted in pump chambers of the main drainage of underground kimberlite mines “Udachniy” and “Mir” is the low mean time between their capital repairs. One of the most negative effects of low magnitude are signifi cant financial costs for the purchase of expensive base parts (impeller, shaft, etc.), ranging from 2 to 5 million rubles for a single pump, depending on its degree of deterioration and the model. Every year on the capital repairs of the sectional pumps of the main drainage of mines expends a total of above 20 million rubles. In connection with the regular reduction of funds for the operation of process and auxiliary equipment, we consider that the increase the overhaul period of operation of pumps of the main drainage of underground kimberlite mines “Udachiy” and «Mir” is one of the priorities for the management of the Udachninskiy and Mirninskiy GOKs “ALROSA”. In the article, using correlation-regression analysis established the most signifi cant factors affecting on durability of unit of hydropath of the sectional pumps underground kimberlite mines, геmoval of the which in longer term will increase the overhaul period of operation of these pumps. Studies have shown that on speed hydroabrasive wear of unit of the hydropath and on the time to failure affects pressure of the sectional pump. To increase the between-repairs periods of the pumps of the main drainage underground kimberlite mines “Udachiy” and “Mir” is necessary to reduce the abrasiveness produced by them is of high-pressure fluid flow, for example by commissioning additional ponds that will improve the process of clarifi cation of the pumped mine water. Also by results of the conducted research is proposed to reduce the acceleration and deceleration of pump units of main drainage of kimberlite underground mine “Mir” to 10 seconds (drainage unit KGW-2).

Ключевые слова Underground mine, sectional pump, wear, overhaul, unit of hydropath, mechanical impurities, pressure
Библиографический список

1. Ovchinnikov N. P., Vikulov M. A., Bochkarev Yu. S., Dovidenko G. P. Experimental studies of operating properties of pumping unit with worn impeller. Gornyi Zhurnal. 2016. No. 9. pp. 85–88. DOI: 10.17580/gzh.2016.09.17
2. Dolganov A. V., Islentev A. O., Churakov E. O., Toropov E. Yu. Analysis of effectiveness of dumping devices of mine centrifugal sectional pumps. Izvestiya Uralskogo gosudarstvennogo gornogo universiteta. 2014. No. 2. pp. 31–35.
3. Timukhin S. A., Dolganov A. V., Popov Yu. V., Cherakov E. O., Islentev A. O. et al. On the development of the mine sectional centrifugal dual-stream pumps. Izvestiya Uralskogo gosudarstvennogo gornogo universiteta. 2014. No. 2. pp. 41–44.
4. Styuflyaev S. S., Shipulin O. G. Comparative analysis of multi-stage centrifugal pump with opposite order of wheels and with hydraulic balancing device. Molodoy uchenyy. 2017. No. 3. pp. 165–171.
5. Povetkin V. V., Lem V. P. Hydroabrasive wear of soil and sand pumps. Vestnik KazNTU. 2008. No. 6. pp. 51–54.
6. Yoganandh J., Natarajan S., Kumaresh Babu S. P. Erosive Wear Behavior of High-Alloy Cast Iron and Duplex Stainless Steel under Mining Conditions. Journal of Materials Engineering and Performance. 2015. Vol. 24, Iss. 9. pp. 3588–3598.
7. Verichev S. N., Mishakin V. V., Nuzhdin D. A., Razov E. N. Experimental study of abrasive wear of structural materials under the high hydrostatic pressure. Ocean Engineering. 2015. Vol. 99. pp. 9–13.
8. Ramkrishna Dandapat, Arghya Deb. A probability based model for the erosive wear of concrete by sediment bearing water. Wear. 2016. Vol. 350-351. pp. 166–181.
9. Kosmin V. G., Patsera S. T., Protsiv V. V. Analysis of reasons of insufficient wear resistance of pumps waterjet mixes. Sovremennye innovatsionnye tekhnologii podgotovki inzhenernykh kadrov dlya gornoy promyshlennosti i transporta. 2015. No. 1. pp. 83–89.
10. Rick Kesler. Considerations is selecting a positive displacement slurry pump. Mining World. 2016. Vol. 13, Iss. 4. pp. 34–37.
11. Kränzler T., Arola R. Improving pump materials for harsh environments. Sulzer Technical Review. 2013. Vol. 2. pp. 10–12.
12. Dolganov A. V. Slurry of copper and pyrites pits: problems and ways of decision. Gornyy informatsionnoanaliticheskiy byulleten. 2013. No. 4. pp. 10–14.
13. Popov V. M. Pumping plants : reference book. Moscow : Nedra, 1990. 254 p.
14. Ostrovskiy V. G., Peshcherenko S. N. Calculations of the rate hydroabrasive wear interstage seal oil pump. Vestnik PNIPU. Geologiya. Neftegazovoe delo. 2012. No. 5. pp. 70–75.
15. Antsiferov S. A., Usmanova E. A. Analysis of the impact of internal corrosion on the operation of pipelines. Vestnik NGIEI. 2015. No. 6. pp. 5–10.
16. Chernova T. V. Economic statistics : tutorial. Taganrog : Izdatelstvo TRTU, 1999. 140 p.
17. LLC “Link-Produkt” : official website. Available at: http://www.linkprodukt.ru/produkciya (accessed: 17.02.2017).

Language of full-text русский
Полный текст статьи Получить
Назад