Журналы →  Gornyi Zhurnal →  2019 →  №12 →  Назад

Название Increase of efficiency of magnetic ore processing by magnetoimpulse treatment
DOI 10.17580/gzh.2019.12.11
Автор Chizhevsky V. B., Petukhov V. N., Fadeeva N. V., Gmyzina N. V.
Информация об авторе

Magnitogorsk State Technical University, Magnitogorsk, Russia:

V. B. Chizhevsky, Professor, Doctor of Engineering Sciences
V. N. Petukhov, Professor, Doctor of Engineering Sciences
N. V. Fadeeva, Associate Professor, Candidate of Engineering Sciences, natali_fadeeva@mail.ru
N. V. Gmyzina, Associate Professor, Candidate of Engineering Sciences


The influence of the conditions of ore pretreatment before grinding on the selectivity of mineral dissociation and separation is estimated. The possibility of intensifying grinding, reducing energy consumption and increasing efficiency of magnetite ore processing due to better dissociation of minerals after magnetoimpulse treatment is shown. The material constitution of magnetite ores from the Maly Kuibas and Techenskoe deposits is studied. The ores are finely disseminated; the size of the magnetite grains reaches a few microns. The microscopic research was carried out on the SIA Mineral C7 installation Photolab. Magnetoimpulse treatment of ores implemented on the installation capable to create the magnetic field strength up to 3.55×102 kA/m and to change parameters of processing cycles. Subsequent grinding was executed on a 1.2 dm3 batch mill with determination of the granulometric composition of the ground products on a mechanical shaker. Wet magnetic separation was performed on electromagnetic tube analyzer 298 SE-00.000PS. The effect of the magnetic field strength, duration of magnetic pulse treatment and the presence of balls, as well as the electric power consumption as per the granulometric composition of the ground ores was studied. The optimum intensity is 1.28×102 kA/m, and the optimum pulse duration is 1 s. The presence of balls during magnetoimpulse treatment intensifies the process of grinding: the size -0.071 mm in the ground ores increases from 47.82 and 44.52% to 61.33 and 54.89% at the simultaneous reduction in the grinding time. The wet magnetic separation of ore ground after МРР increases the mass fraction of iron in the magnetic product from 60.89 and 58.61% to 62.09 and 59.61% at the rise I recovery from 70.36 and 66.56% to 74.32 and 69.28%, which is due to the better dissociation of intergrown minerals.

Ключевые слова Magnetite ore, grinding, intensification, selective disintegration, accretions, dissociation, magnetic separation, magnetic pulse treatment, magnetic field, strength, power consumption
Библиографический список

1. Bunin I. Zh. High-power nanosecond electromagnetic impulses and application in mineral disintegration. GIAB. 2008. No. 2. pp. 376–391.
2. Korobeinikov M. V., Bryazgin A. A., Bezuglov V. V., Shtarklev E. A., Vlasov A. Yu. et al. Radiation-Thermal Treatment in Ore Dressing. IOP Conference Series: Materials Science and Engineering. 2015. Vol. 81. 012124.
3. Somani A., Nandi T. K., Pal S. K., Majumder A. K. Pre-treatment of rocks prior to comminution – A critical review of present practices. International Journal of Mining Science and Technology. 2017. Vol. 27, Iss. 2. pp. 339–348.
4. Vaisberg L. A. Disintegration and separation of natural and artificial materials as a raw material base for additive technologies. Current problems of inte gral processing of complex ores and technogenic raw materials (Plaksin Readings – 2017) : Proceedings of the international conference. Krasnoyarsk : Sibirskiy federalnyi universitet, 2017. pp. 6–7.
5. Chanturiya V. A., Chaplygin N. N., Vigdergauz V. E. Up-to-date directions in the field of development of resource-saving technologies and environment protection in processing of mineral raw materials. Gornyi Zhurnal. 2007. No. 2. pp. 91–96.
6. Chanturiya V. A. Innovation processes in technologies for the processing of refractory mineral raw materials. Geology of Ore Deposits. 2008. Vol. 50, No. 6. pp. 491–501.
7. Chanturiya V. A., Kozlov A. P. Current problems of integral processing of complex ores and technogenic raw materials. Current problems of integral processing of complex ores and technogenic raw materials (Plaksin Readings – 2017) : Proceedings of the international conference. Krasnoyarsk : Sibirskiy fereralnyi universitet, 2017. pp. 3–6.
8. Samerkhanova A. S. Improving the efficiency of magnetic pulse ores treatment for the purpose of their softening before grinding : thesis of inauguration of Dissertation … of Candidate of Engineering Sciences. Moscow, 2010. 23 p.
9. Azimov O. A. Improving the efficiency of minerals disintegration using magnetic pulse treatment : thesis of inauguration of Dissertation … of Candidate of Engineering Sciences. Moscow, 2009. 20 p.
10. Bunin I. Zh. Theoretical basis of the nanosecond electromagnetic pulses impact on the processes of disintegration and disclosure of fine mineral complexes of precious metals from ores : Dissertation … of Doctor of Engineering Sciences. Moscow, 2009. 345 p.
11. Chanturiya V. A., Bunin I. J., Kovalev A. T. Mechanisms of disintegration of mineral media exposed to high-power electromagnetic pulses. Computational Methods : Proceedings of the First International Conference. Dordrecht : Springer, 2006. pp. 1607–1614.
12. Anisimov V. N., Morozov V. N. Magnetokinetic effect of ferruginous quartzite destruction. Zapiski Gornogo instituta. 2007. Vol. 171. pp. 66–69.
13. Goncharov S. A. Physical and technical bases of the resource-saving by the destruction of rocks. Мoscow : Izdatelstvo MGGU, 2007. 211 p.
14. Khopunov E. A. Selective destruction of mineral and anthropogenic raw materials (in mineral dressing and metallurgy). Ekaterinburg : UIPTs, 2013. 429 p.
15. Mehdilo A., Irannajad M., Rezai B. Chemical and mineralogical composition of ilmenite: Effects on physical and surface properties. Minerals Engineering. 2015. Vol. 70. pp. 64–76.
16. Yu Jian-wen, Han Yue-xin, Li Yan-jun, Gao Peng. Effect of magnetic pulse pretreatment on grindability of a magnetite ore and its implication on magnetic separation. Journal of Central South University. 2016. Vol. 23, Iss. 12. pp. 3108–3114.
17. Chizhevskiy V. B., Shavakuleva O. P. Effect of magnetic pulse treatment upon titanium magnetite ore grindability and crushability. Obogashchenie Rud. 2016. No. 4. pp. 3–9. DOI: 10.17580/or.2016.04.01
18. Chizhevskiy V. B., Grishin I. A., Shavakuleva O. P. Development of high-efficient technologies of deep processing and comprehensive utilization of steel slags. Chernye Metally. 2016. No. 9. pp. 18–23.
19. Bruev V. P. Physicotechnical substantition of electromagnetic impulse treatment of ferruginous quartzites for softening before milling : thesis of inauguration of Dissertation … of Candidate of Engineering Sciences. Moscow, 2005. 26 p.
20. Chizhevskiy V. B., Sedinkina N. A., Shavakuleva O. P. Energy-saving pretreatment technologies for magnetite ore. Latest Scientific Achievements–2015 : XI International Scientific–Practical Conference Proceedings. Sofia : ByalGRAD-BG OOD, 2015. Vol. 15. pp. 49–52

Language of full-text русский
Полный текст статьи Получить