Журналы →  Obogashchenie Rud →  2015 →  №1 →  Назад

Название A treatability study of the Bakcharskoye deposit iron ores concentration by means of high-intensity magnetic separation
Автор Lvov V. V., Kuskov V. B.
Информация об авторе

National Mineral Resources University (University of Mines) (Russia):

Lvov V. V., Ph. D. in Engineering Sciences; Associate Professor, opilvv@mail.ru
Kuskov V. B., Ph. D. in Engineering Sciences; Associate Professor, opikvb@mail.ru


Study of possible prospects of drawing the Siberian Federal District iron ore deposits into mining and processing is considered to be an important long-range objective. This will permit to considerably decrease nonoptimal transportation of mined iron ore to long distances and promote industrial development in the District. The paper considers the Bakcharskoye iron ore deposit with prognostic resources of approximately 23 billion tons, the ores’ mass fraction of iron is 40 %. The ores are characterized by a higher vanadium content. A major hindrance in the deposit ores processing is caused by a higher-than-average phosphorus content. The paper presents the data obtained in the studies aimed at saleable concentrates production using fine grinding with subsequent magnetic separation in high-gradient magnetic separators of various types. The studies showed, that magnetic concentration of iron by means of high-gradient magnetic separators is possible in principle. However, the state-of-art physical-and-mechanical methods of fine grinding and high-gradient magnetic separation, tested in the reported stage of the studies, did not allow for removal of phosphorus from the Bakcharskoye deposit oxide iron ores.

The study was performed in the framework of the State task No. 5.1284.2014/K, dated the 11th of July, 2014, «Development of mineral resources reproduction technologies with a view to utilize man-caused mining and metals production sector wastes and formations in the Russian Federation with recovery of valuable components and output of additional marketable products».

Ключевые слова Promising iron ore deposits, oxide iron ores, removal of phosphorus, fine and ultrafine grinding, high-gradient magnetic separation
Библиографический список

1. Mazurov A. K., Boyarko G. Yu., Ananyev A. A., Yemeshev V. G. Prospects for development of iron ore deposits of Tomsk Region. Mineralnyye Resursy Rossii. Ekonomika i Upravleniye = Mineral Resources of Russia. Economics and Management, 2005, No. 5, pp. 16–20.

2. Maksimov I. I., Sentemova V. A., Akkerman Yu. E. Studies and development of energy-saving technology for high-grade concentrates production from oxidized iron ores. Obogashchenie Rud, 2011, No. 6, pp. 3–7.
3. Maksimov I. I., Sentemova V. A. Special features of high-magnetite oxidized ferruginous quartzites processing technology. Obogashchenie Rud, 2012, No. 3, pp. 7–10.
4. Levintov B. L., Mirko V. A., Kantemirov M. D., Klimushkin A. N., Naydenov V. A., Bobir A. V. Structural features of limonite oolites and their impact on effectiveness of Lisakovsk concentrates thermochemical beneficiation. Stal' = Steel, 2007, No. 8, pp. 8–11.
5. Sankay A. N., Balapanov M. K., Mukhymbekova M. K. Beneficiation of Lisakovsk iron ore. Gorny Informatsionno-Analiticheskiy Byulleten (GIAB) = Mining Informational and Analytical Bulletin, 2005, No. 6, pp. 317–321.
6. David D., Larson M., Le M. Optimising Western Australia magnetite circuit design. Metallurgical Plant Design and Operating Strategies. Melbourne, Australasian Institute of Mining and Metallurgy, 2011, pp. 552–562.
7. Anderson G. S., Burford B. D. IsaMill — the crossover from ultrafine to coarse grinding. Metallurgical Plant Design and Operating Strategies (Metplant 2006), 18 to 19 September 2006, Perth, Western Australia.
8. Http://www.kroosh.com/ru/category/sitovye-analizatory.
9. Karmazin V. V., Karmazin V. I. Magnitnyye, elektricheskiye i spetsialnyye metody obogashcheniya poleznykh iskopayemykh. Uchebnik dlya vuzov (Magnetic, electrical and special methods of mineral processing. Textbook for higher schools). In 2 Vols. Vol. 1. Magnitnyye i elektricheskiye metody obogashcheniya poleznykh iskopayemykh (Magnetic and electrical methods of mineral processing). Moscow, MGGU (Moscow State Mining University), 2005, 669 p.
10. Dobbins M., Hearn S. SLon® magnetic separator: A new approach for recovering and concentrating iron ore fines. Canadian Institute of Mining, Metallurgy and Petroleum Conference and Exhibition, April 29 – May 2, 2007, Montreal, Canada.

Language of full-text русский
Полный текст статьи Получить